碱度和MgO质量分数对球团抗压强度的影响

doi:10.13228/j.boyuan.issn1006-9356.20190594

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (3422 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要为研究含镁熔剂性球团的抗压强度,在实验室条件下,研究了焙烧时间、球团矿碱度和MgO质量分数对球团矿抗压强度的影响。试验研究结果表明,膨润土质量分数保持2.0%不变时,含镁熔剂性球团矿碱度(R)为0.80~1.00、MgO质量分数为1.60%~1.80%,焙烧时间为25 min,球团矿的黏结相以Fe₃O₄氧化为Fe₂O₃、然后Fe₂O₃再结晶为主。另外,还有少量的铁酸镁、铁酸钙相,这种球团矿的抗压强度大于2 500 N/个。当含镁熔剂性球团的矿碱度大于1.00,同时,MgO质量分数小于1.60%时,球团矿的黏结相含有大量的玻璃体硅酸盐,使球团矿的抗压强度大大降低。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	作者相关文章
	杨福

关键词 ：含镁熔剂性球团, 碱度, MgO质量分数, 抗压强度

Abstract：In order to research the compression strength of magnesium-containing fluxed pellets,the effect of roasting time,basicity of pellets and MgO mass fraction on the strength of pellets were investigated under laboratory conditions. The results show that when the mass fraction of bentonite remains unchanged at 2.0%,the basicity of magnesium-containing fluxed pellets is 0.80-1.00,the MgO mass fraction is 1.60%-1.80%,and the roasting time is 25 min,the bonding phase of pellets is mainly composed of the recrystallization Fe₂O₃,which is the oxidation product of Fe₃O₄. In addition,there is a small amount of magnesium ferrite and calcium ferrite. Pellets with the compressive strength greater than 2 500 N/p can be obtained. When the basicity of magnesium-containing fluxed pellets is larger than 1.00,at the same time,the MgO mass fraction is less than 1.60%,a large amount of glassiness silicate is produced in the binding phase of pellets,which greatly reduces the compressive strength of pellets.

Key words： magnesium-containing fluxed pellets basicity MgO mass fraction compression strength

收稿日期: 2019-12-17

基金资助:湖北省教育厅科学研究计划指导性资助项目(B2017002)

作者简介: 杨福(1976—), 男, 博士, 讲师; E-mail: 542734663@qq.com

引用本文:

杨福. 碱度和MgO质量分数对球团抗压强度的影响[J]. 中国冶金, 2020, 30(6): 19-23. YANG Fu. Effects of basicity and MgO mass fraction on compression strength of pellets[J]. China Metallurgy, 2020, 30(6): 19-23.

链接本文:

http://www.zgyj.ac.cn/CN/10.13228/j.boyuan.issn1006-9356.20190594 或 http://www.zgyj.ac.cn/CN/Y2020/V30/I6/19

[1]	姜涛,范晓慧,李光辉. 熔剂性球团矿生产的理论与技术[C]//全国炼铁生产技术会暨炼铁学术年会论文集. 郑州:中国金属学会,中国金属学会炼铁分会,2014:92.
[2]	潘建,于鸿宾,朱德庆,等. MgO含量及来源对磁铁精矿球团固结行为的影响[J]. 中南大学学报:自然科学版,2016,47(9):2914.
[3]	周明顺,唐复平,赵东明,等. 球团配加镁质熔剂及新型皂土试验[J]. 钢铁,2018,53(4):15.
[4]	吴胜利,韩宏亮,姜伟忠,等. 烧结矿中MgO作用机理[J]. 北京科技大学学报:自然科学版,2009,31(4):428.
[5]	田筠清,青格勒,刘长江,等. 使用石灰石生产低硅碱性球团矿试验[J]. 中国冶金,2018,28(4):13.
[6]	Dwarapudi S,Ghosh T K,Shankar A,et al. Effect of pellet basicity and MgO content on the quality and microstructure of hematite pellets[J]. International Journal of Mineral Processing,2011,99(1):43.
[7]	Dwarapudi S,Ghosh T K,Shankar A,et al. Effect of pyroxenite flux on the quality and microstructure of hematite pellets[J]. International Journal of Mineral Processing,2010,96(1):45.
[8]	Nogueira P F,Fruehan R J. Blast furnace burden softening and melting phenomena-Melting onset in acid and basic fluxed pellets[J]. Iron and Steelmaker,2003,30(7):29.
[9]	张永明,贾彦忠. 熔剂性含MgO球团矿特点及生产实践[C]//2004年全国炼铁生产技术会议暨炼铁年会文集. 无锡:中国金属学会,2004:255.
[10]	周明顺,沈峰满,翟立委,等. MgO添加方式对改善球团矿冶金性能的影响[J]. 钢铁,2012,47(4):14.
[11]	王天雄. 熔剂性球团的生产试验[J]. 烧结球团,2012,37(2):49.
[12]	李坤,王昌华. 石灰石熔剂性球团试验研究[J]. 烧结球团,2015(2):32.
[13]	国家技术监督局. GB/T 14201－1993 铁矿球团矿抗压强度测定方法[S]. 北京:中国标准出版社,1993.
[14]	GAO Q J,SHEN F M,GUO W,et al. Effects of MgO containing additive on low-temperature metallurgical properties of oxidized pellet[J]. Journal of Iron and Steel Research,International,2013,20(7):25.
[15]	张汉泉. 熔剂性球团的生产及发展[J]. 中国矿业,2009,18(4):89.